Solar Water Heater Maintenance Checklist

Among the parts that should be checked regularly on your solar water heater are pumps valves and their controls insulation wiring pipes seals and the state of the solar collector.

Solar water heater maintenance checklist. Let the water run until it stops flowing. Use a solution of dish soap and warm. 1 temperature of hot water. Solar hot water heaters are no different except that because they have more components there is more that can go wrong.

Drain the water from the hot water pipe. Solar storage tank water heater installation instructions and use care guide to obtain technical warranty or service assistance during or after the installation of this solar storage tank water heater reference the phone number on the warranty sheet that ships with the water heater. If water is milky drain entire tank. Don t miss the temperature and pressure valves.

Two major factors affecting the performance of properly sited and installed solar. Close drain valve and open cold water supply valve. Satisfactory not satisfactory 2 quantity of hot water supply. Install pump onto the water heater discharge using pipe fitting.

Solar water heating system maintenance and repair periodic inspection list. Turn off cold water supply and open drain valve. If it is then you are set to refill the tank. Check to make sure the water to the hot water heater has been completely shut off.

Turn off the heat. Allow a few gallons worth of water to drain. With pressure valve still open turn on the water to the water tank and then turn on the water drain to allow the rest of the sediment to be flushed out. Here are some suggested inspections of solar system components.

Open t p relief valve to relieve pressure. Open a hot water. Checking the solar collectors and frames for damage noting broken or leaking tubes for replacement ensuring valves are in proper positions inspecting pipe insulation to minimize losses and maintain freeze protection checking mounting connectors for. Regularly scheduled maintenance should include.

Also read your owner s manual. When calling for assistance please have the following. Satisfactory not satisfactory 3 constant temperature e g. Before you begin inspect all of the valves.

The pump should be installed so that the pump is pumping away from the hot water heater towards the solar panel. Preventing scaling and corrosion. Be sure to check the water draining out and make sure it is clear. Whether the tank is gas or electric turn off its heating source the night before.

Drain 2 3 gallons of water.